油站老板必看！油气回收设备不是摆设，是合规盈利的“隐

　　Gas station owners must watch! Oil and gas recovery equipment is not just a decoration, but a "hidden" means of compliance and profitability

　　很多油站老板都有个误区：油气回收设备是“多余的负担”，装了只是为了应付检查，能省则省。郑哥今天实打实提醒各位：油站油气回收设备真不是摆设，而是刚需中的刚需，是油站合规经营的“保命符”，更是能省能赚的“隐形摇钱树”。不管是民营小油站，还是连锁加油站，只要开门营业，就必须按规安装，今天就用大白话讲透其中门道，结合真实数据和实操要点，油站老板们看完，就知道这设备装得有多值。

　　Many gas station owners have a misconception: oil and gas recovery equipment is an "unnecessary burden", installed only to cope with inspections, and saved as much as possible. Zheng Ge reminds everyone today that oil and gas recovery equipment at gas stations is not just a decoration, but a must-have among essential needs. It is a "life-saving talisman" for compliant operation of gas stations and a "hidden money tree" that can save and earn. Whether it is a private small gas station or a chain gas station, as long as it opens for business, it must be installed according to regulations. Today, we will explain the process in plain language, combined with real data and practical points. After reading it, gas station owners will know how valuable this equipment is.

　　先给大家划重点：油气回收设备，是国家强制要求油站必须安装的环保设施，绝非可装可不装。根据GB20952-2020《加油站大气污染物排放标准》，明确要求油站非甲烷总烃排放浓度≤25g/m?，未安装油气回收设备的油站，一律不准通过环评验收，更不能正常营业——截至目前，全国已有超1.2万家油站因未安装或未规范使用该设备，被责令停业整改，济南本地也有37家油站因违规被处罚，罚款金额从1万元到20万元不等，严重者直接吊销经营许可证，这笔损失可比装设备大多了。

　　First of all, let me emphasize that oil and gas recovery equipment is an environmental protection facility that the country requires gas stations to install, and it is not optional. According to GB20952-2020 "Emission Standards for Air Pollutants from Gas Stations", it is explicitly required that the concentration of non methane total hydrocarbon emissions from gas stations be ≤ 25g/m? Oil stations that have not installed oil and gas recovery equipment are not allowed to pass environmental impact assessment and acceptance, nor can they operate normally. As of now, more than 12000 oil stations in China have been ordered to suspend operations and rectify due to the failure to install or use the equipment in a standardized manner. There are also 37 gas stations in Jinan that have been punished for violations, with fines ranging from 10000 yuan to 200000 yuan. In severe cases, their operating licenses will be revoked, and this loss is much greater than installing equipment.

　　可能有老板会问：花 money 装设备，到底图啥？核心就是三点：合规、环保、省成本，三者缺一不可。加油时挥发出的油气，不仅会污染空气，还存在极大的安全隐患——据应急管理部统计，国内加油站80%的安全事故都与油气泄漏相关，而油气回收设备能高效回收这些挥发的油气，回收效率可达95%以上，既减少了大气污染，规避了安全风险，还能轻松通过环保督查和环评验收，让油站安心营业，不用再担心被罚款、被停业。

　　Some bosses may ask: What is the purpose of spending money to install equipment? The core is three points: compliance, environmental protection, and cost saving, all of which are indispensable. The oil and gas emitted during refueling not only pollute the air, but also pose great safety hazards - according to statistics from the Ministry of Emergency Management, 80% of safety accidents at domestic gas stations are related to oil and gas leaks. Oil and gas recovery equipment can efficiently recover these volatile oils and gases, with a recovery efficiency of over 95%. This not only reduces air pollution and avoids safety risks, but also easily passes environmental inspections and environmental impact assessments, allowing gas stations to operate with peace of mind without worrying about fines or closures.

　　更关键的是，这设备能帮油站“省钱盈利”，把浪费的钱硬生生省回来。大家都知道，汽油挥发性极强，一辆车加油的几分钟里，就会有少量汽油挥发成油气，看似不起眼，日积月累就是一笔不小的损耗。数据显示，未安装油气回收设备的油站，年油品损耗率可达0.8%-1.2%，一家日均加油10吨的油站，一年损耗的汽油就达30多吨，按当前油价计算，年损失超20万元；而安装合格的油气回收设备后，损耗率可降至0.2%以下，一年能省15-18万元，相当于设备成本几年内就能轻松回本。

　　More importantly, this equipment can help gas stations "save money and make profits" by forcefully saving wasted money. As we all know, gasoline has extremely high volatility. Within a few minutes of refueling a car, a small amount of gasoline will evaporate into gas, which may seem insignificant but accumulates over time into a significant loss. Data shows that gas stations without installed oil and gas recovery equipment have an annual oil loss rate of 0.8% -1.2%. A gas station that refuels 10 tons per day consumes more than 30 tons of gasoline per year. Based on current oil prices, the annual loss exceeds 200000 yuan; After installing qualified oil and gas recovery equipment, the loss rate can be reduced to below 0.2%, saving 150000 to 180000 yuan per year, which is equivalent to easily recovering equipment costs within a few years.

　　而且回收的油气并非无用，经过处理后可以重新利用，要么回炼成汽油，要么转化为能源供油站自用，进一步降低运营成本。山东某连锁加油站（10家门店）2024年批量安装油气回收设备后，实测单站年回收油气超5吨，折算成汽油可直接挽回成本约20万元，同时VOCs排放浓度≤10g/m?，仅为国家限值的40%，既合规又盈利，一举两得。

　　Moreover, the recovered oil and gas are not useless. After processing, they can be reused, either by refining them into gasoline or converting them into energy for use in fuel supply stations, further reducing operating costs. After installing oil and gas recovery equipment in batches at a chain of gas stations (10 stores) in Shandong in 2024, it was tested that the annual recovery of oil and gas at a single station exceeded 5 tons. Converted into gasoline, the cost can be directly recovered by about 200000 yuan, and the VOCs emission concentration is ≤ 10g/m? Only 40% of the national limit, it is both compliant and profitable, killing two birds with one stone.

　　郑哥必须重点提醒：油气回收设备装了不算完，定期检测才是关键，不然照样会被罚款。很多油站老板装完设备就不管不问，设备老化、故障后无法正常工作，被环保部门检查发现，照样会面临1-10万元的罚款，得不偿失。根据规定，油站油气回收设备每6个月需检测一次，每年进行一次全面检修，确保回收效率和排放达标，这也是很多油站老板容易忽略的细节。

　　Zheng Ge must emphasize that the installation of oil and gas recovery equipment is not complete, regular testing is the key, otherwise fines will still be imposed. Many gas station owners do not pay attention to the equipment after installation, and if the equipment ages or malfunctions and cannot work properly, they will still face fines of 10000 to 100000 yuan if it is discovered by environmental protection departments during inspections, which is not worth the loss. According to regulations, the oil and gas recovery equipment at gas stations needs to be inspected every 6 months and undergo comprehensive maintenance once a year to ensure recovery efficiency and emission standards. This is also a detail that many gas station owners tend to overlook.

　　考虑到很多油站老板没时间、没精力处理安装和检测的琐事，我们推出一站式服务，包安装、包检测，全程不用老板费心，从设备选型、现场安装，到定期检测、故障维修，一步到位，确保设备始终正常运行，让油站既能顺利通过环保检查，又能安心省成本、赚收益。

　　Considering that many gas station owners do not have the time or energy to handle the trivial matters of installation and testing, we have launched a one-stop service that includes installation and testing. The entire process does not require the boss's effort, from equipment selection and on-site installation to regular testing and troubleshooting. We ensure that the equipment always operates normally, allowing the gas station to pass environmental inspections smoothly while saving costs and earning profits with peace of mind.

　　可能还有老板纠结：装设备会不会很麻烦，影响正常营业？完全不用担心。现在的油气回收设备采用模块化集成设计，外形紧凑，适配油站狭小场地，安装周期缩短至3天内，不会耽误油站正常经营；而且运行噪音低、能耗小，实测单位耗电量低至0.2kWh/m?，比传统设备节能20%，月均电费仅增加几百元，相比每年节省的损耗成本，几乎可以忽略不计。

　　Perhaps the boss is still undecided: Will installing equipment be troublesome and affect normal business operations? Don't worry at all. The current oil and gas recovery equipment adopts a modular integrated design, with a compact appearance and adaptability to the narrow space of gas stations. The installation cycle is shortened to within 3 days, which will not delay the normal operation of gas stations; And it has low operating noise and low energy consumption, with a measured unit power consumption as low as 0.2 kWh/m? Compared to traditional equipment, it saves 20% energy and only increases monthly electricity bills by a few hundred yuan. Compared to the annual cost savings, it can be almost negligible.

　　总结一下，油站油气回收设备，不是“负担”，而是油站合规经营的前提、降低损耗的关键、隐形盈利的抓手。对油站老板来说，装设备不是“被动应付”，而是“主动盈利”，既能规避罚款、停业风险，又能减少油品损耗、回收再利用，实现合规与盈利两不误。郑哥在这里再叮嘱一句：装设备要选靠谱的，检测要按时做，有任何相关问题，都可以来找我喝茶聊聊天，我帮你一站式搞定，让你省心、省力、省成本，安心做好生意。

　　To sum up, the oil and gas recovery equipment at gas stations is not a burden, but a prerequisite for compliant operation, a key to reducing losses, and a lever for hidden profits. For gas station owners, installing equipment is not a "passive response", but an "active profit". It can not only avoid fines and business closure risks, but also reduce oil loss and recycling, achieving compliance and profitability. Zheng Ge would like to remind you again: choose reliable equipment for installation, conduct testing on time, and if you have any related questions, you can come to me for tea and chat. I will help you solve them in one stop, making you worry free, labor-saving, and cost-effective, and doing business with peace of mind.

　　本文由  油气回收设备  友情奉献.更多有关的知识请点击  http://www.kosman.com.cn/   真诚的态度.为您提供为全面的服务.更多有关的知识我们将会陆续向大家奉献.敬请期待.

　　This article is a friendly contribution from oil and gas recovery equipment For more related knowledge, please click http://www.kosman.com.cn/ Sincere attitude To provide you with comprehensive services We will gradually contribute more relevant knowledge to everyone Coming soon.